Kajian Laboratorium Kuat Tarik Belah Beton Egg Tray Dengan Penambahan Superplasticizer: Laboratory Study Of Split Tensile Strength Of Egg Tray Concrete With The Addition Of Superplasticizer

Jusuf Wilson Meynerd Rafael; Alva Yuventus Lukas

Authors

Jusuf Wilson Meynerd Rafael Politeknik Negeri Kupang
Alva Yuventus Lukas Politeknik Negeri Kupang

Keywords:

Beton Ramah Lingkungan, Kuat Tarik Belah, Limbah Egg Tray, Superplasticizer

Abstract

Using egg tray waste as a fine aggregate substitute can be an alternative for making environmentally friendly concrete. The weaknesses of concrete with egg trays can corrected by adding a superplasticizer to both the compressive strength and split tensile strength of the concrete. This study used an egg tray waste as a fine aggregate substitution of 3% with variations in superplasticizer content. The test specimens were by a concrete cylinder with a diameter of 15 cm and a height of 30 cm, which varied the superplasticizer content by 0%, 0.5%, 1%, 1.5%, 2%, and 5% compared to normal concrete conditions. The test results show that concrete given a 3% egg tray waste as a substitute for fine aggregate has a lower split tensile strength value than normal concrete. Adding superplasticizer material can increase the value of split tensile strength up to 1% superplasticizer content. As the superplasticizer content increases, the value of the split tensile strength will again decrease.

Downloads

Download data is not yet available.

References

Agarwal, N, Garg, N., 2016, “A Research on Green Concrete”, International Journal of Innovation Research in Engineering & Multidisciplinary Physical Sciences, [e-journal] 4(4), pp. 1-17.

Al-Azzawl, A.A, Al-Azzawl, A.A., 2020, “Mechanical Properties of Green Concrete”, Proceeding of International Conference on Civil and Environmental Engineering Technologies, pp. 1-9.

Mohammad, N, Lakhiar, M.T, Samad, A.A.A, Mydin, M.A.O, Jhatial, A.A, Sofia, S.A, Goh, W.I, Ali, N., 2019, “Innovative and Sustainable Green Concrete – A Potential Review on Utilization of Agricultural Waste”, Proceedings of Postgraduate Symposium in Civil and Environmental Engineering, pp. 184-195.

Saadon, A.S., Abbas, A.M., Almaya, A.A., 2019, “Revision Study of Green Concrete”, Basrah Journal for Engineering Sciences, 19(2), pp. 33-38.

Pradana, A, Haq, B.N, Kurniawan, O., 2019, “Pemanfaatan Limbah Tempat Telur untuk Furnitur”, Jurnal IKRA-ITH Teknologi, 3(3), pp. 14-22.

Kurniasih, P., 2013, “Kelayakan Usaha Pembuatan Produk Kemasan Telur Dari Kertas Limbah di Sumatera Barat”, Jurnal Penelitian Sosial dan Ekonomi Kehutanan, 10(3), pp. 157-172.

Handoko, E, Munir, A.P, Panggabean, S., 2018, “Rancang Bangun Alat Pencetak Rak Telur Puyuh”, Jurnal Rekayasa Pangan dan Pertanian, 6(1), pp. 171-176.

Badan Pusat Statistik., 2023, “Produksi Telur Ayam Petelur Menurut Provinsi Tahun 2020-2022”, Badan Pusat Statistik.

Rafael, J., Alokabel, K., Lukas, A., Mata, A., 2021, “The Partial Substitution Influence of Fine Aggregate with Egg Tray Waste in the Green Concrete Production”, Proceedings of the 4th International Conference on Applied Science and Technology on Engineering Science iCAST-ES, 1, pp. 1023-1027.

Rafael, J.W.M., Lukas, A.Y., Mata, A.E., Daga, W.M.W.L., 2022, “Pengaruh Penambahan Superplasticizer Pada Beton Dengan Limbah Egg Tray Terhadap Kuat Tekan Beton Untuk Pembuatan Beton Ramah Lingkungan”, Jurnal Teknik Sipil, 7(2), pp. 69-73.

Putra, D.M, Widjaja, D., 2015, “Hubungan Kuat Tarik Belah dengan Kuat Tekan Beton Ringan dengan Crumb Rubber dan Pecahan Genteng”, Jurnal Rekayasa Sipil, 4(2), pp. 76-88.

Untu, G.E, Kumaat, E.J, Windah, R.S., 2015, “Pengujian Kuat Tarik Belah dengan Variasi Kuat Tekan Beton”, Jurnal Sipil Statik, 3(10), pp. 703-708.

Putra, A.K, Wallah, S.E, Dapas, S.O., 2014, “Kuat Tarik Belah Beton Geopolymer Berbasis Abu Terbang (Fly Ash)”, Jurnal Sipil Statik, 2(7), pp. 330-336.

Supit, F.V, Pandaleke, R, Dapas, S. O., 2016, “Pemeriksaan Kuat Tarik Belah Beton dengan Variasi Agregat yang Berasal dari Beberapa Tempat di Sulawesi Utara”, Jurnal Ilmiah Media Engineering, 6(2), pp. 476-484.

Dalati, R, Matar, P, Shaddad, S, Chehade, F.H., 2011, “Relationship between the Compressive and Tensile Strength of Recycled Concrete”, Advanced Materials Research, 324, pp. 348-351.

Pratama, E, Hisyam, E.S., 2016, “Kajian Kuat Tekan dan Kuat Tarik Belah Beton Kertas (Papercrete) dengan Bahan Tambah Serat Nylon”, Jurnal Fropil, 4(1), pp. 27-39.